Zen and the Art of Vehicle Maintenance
Moderators: Freakzilla, ᴶᵛᵀᴬ, Omphalos
- Freakzilla
- Lead Singer and Driver of the Winnebego
- Posts: 18454
- Joined: 05 Feb 2008 01:27
- Location: Atlanta, Georgia, USA
- Contact:
Zen and the Art of Vehicle Maintenance
I just replaced the A/C blower motor in my 1995 Cadillac Deville.
The part was $225... for a fan with a motor. If this part costs so god damned much why am I replacing it? Oh yeah, my nuts are freezing to the leather seats.
People who write instructions for installing autoparts should be publicly flogged. "Remove part to be replaced. Install new part." No shit. What they don't tell you is that there isn't room between the A/C duct the blower goes in and the engine to remove or install it. Neither do they mention the various wires and hoses that run between the two. I broke the old blower motor, I had to to get it out. I figured, there's got to be a trick to it. You know, insert it at just the right angle while twisting. Nope.
I finally gave up and went inside to read the automotive forums. I discovered that the manufacturer (GM) conveniently included lines on the A/C duct where you are supposed to cut it away in order to replace the blower. Obviously they thought about the situation enough to include lines on the A/C duct to tell you where to cut. Hey GM, you know what would have really been convenient? If you cut it yourself and put it back on with a couple of fucking screws.
So, thank Gildur for my trust Dremel tool with the rotary cutting disk, which made short work of it. Once I figured out I had to vandelize it the installatino went pretty eazy. I temporarily covered up the lines I cut with some electrical tape and I now have heat! More important though than my comfort, I now have defrost and can actually see where I'm going. Defrost is important in Georgia where it can be 20 degrees at night and 60 in the day, there's almost always some kind of condensation.
But while trying to molest that thing into its hole I knocked loose the wire to the Manifold Absolute Pressure sensor. I found this out after leaving for work and noticing my check engine light was on. So I turned around and went back home (I was already late) to fix that. One other thing GM conveniently equipped my car with is on-board diagnostics that display on the dashboard. I just happened to have a list of trouble codes, which told me it was the MAP, which I located in the manual, then on the car and plugged back in.
I get back in the car and head off to work and it seems a cylinder is not firing. But my nuts are warm. I think I must have knocked one of the spark plug wires off of the clip that keeps it from touching the engine, melting the insulation and grounding/shorting out. But fuck it, it's got seven other cylinders, I'll fix that tonight, replacing a spark plug wire is easy, coparatively.
Now my question is, why cant they make the spark plug wire insulation out of something that won't melt? "Circuit Integrity" cable used in fire alarm systems will last two hours IN A FIRE.
I guess they have to cut costs so they can pay for Viagra for UAW workers.
OK, I feel better now.
The part was $225... for a fan with a motor. If this part costs so god damned much why am I replacing it? Oh yeah, my nuts are freezing to the leather seats.
People who write instructions for installing autoparts should be publicly flogged. "Remove part to be replaced. Install new part." No shit. What they don't tell you is that there isn't room between the A/C duct the blower goes in and the engine to remove or install it. Neither do they mention the various wires and hoses that run between the two. I broke the old blower motor, I had to to get it out. I figured, there's got to be a trick to it. You know, insert it at just the right angle while twisting. Nope.
I finally gave up and went inside to read the automotive forums. I discovered that the manufacturer (GM) conveniently included lines on the A/C duct where you are supposed to cut it away in order to replace the blower. Obviously they thought about the situation enough to include lines on the A/C duct to tell you where to cut. Hey GM, you know what would have really been convenient? If you cut it yourself and put it back on with a couple of fucking screws.
So, thank Gildur for my trust Dremel tool with the rotary cutting disk, which made short work of it. Once I figured out I had to vandelize it the installatino went pretty eazy. I temporarily covered up the lines I cut with some electrical tape and I now have heat! More important though than my comfort, I now have defrost and can actually see where I'm going. Defrost is important in Georgia where it can be 20 degrees at night and 60 in the day, there's almost always some kind of condensation.
But while trying to molest that thing into its hole I knocked loose the wire to the Manifold Absolute Pressure sensor. I found this out after leaving for work and noticing my check engine light was on. So I turned around and went back home (I was already late) to fix that. One other thing GM conveniently equipped my car with is on-board diagnostics that display on the dashboard. I just happened to have a list of trouble codes, which told me it was the MAP, which I located in the manual, then on the car and plugged back in.
I get back in the car and head off to work and it seems a cylinder is not firing. But my nuts are warm. I think I must have knocked one of the spark plug wires off of the clip that keeps it from touching the engine, melting the insulation and grounding/shorting out. But fuck it, it's got seven other cylinders, I'll fix that tonight, replacing a spark plug wire is easy, coparatively.
Now my question is, why cant they make the spark plug wire insulation out of something that won't melt? "Circuit Integrity" cable used in fire alarm systems will last two hours IN A FIRE.
I guess they have to cut costs so they can pay for Viagra for UAW workers.
OK, I feel better now.
Paul of Dune was so bad it gave me a seizure that dislocated both of my shoulders and prolapsed my anus.
~Pink Snowman
- GamePlayer
- 70mm God
- Posts: 2993
- Joined: 09 Feb 2008 11:26
- Location: Toronto, Ontario, Canada
Re: Zen and the Art of Vehicle Maintenance
Well, it was all worth it thenFreakzilla wrote:But my nuts are warm.
OK, I feel better now.
"They can chew you up, but they gotta spit you out."
- Drunken Idaho
- Posts: 1197
- Joined: 15 Sep 2008 23:56
- Location: Ontario, Canada
That sucks... I just had to cough up $500 for my engine this week. One of the coils wasn't firing, and it wasn't covered under warranty. Plus, the guy said that once one coil goes, the other one follows son after, so I had them both replaced. Now she's running better. It's a 2003 Mazda Protege 5, by the way:
"The Idahos were never ordinary people."
-Reverend Mother Superior Alma Mavis Taraza
-Reverend Mother Superior Alma Mavis Taraza
- Freakzilla
- Lead Singer and Driver of the Winnebego
- Posts: 18454
- Joined: 05 Feb 2008 01:27
- Location: Atlanta, Georgia, USA
- Contact:
I guess it has a coil pack on each side, one for each bank of cylinders?
I'd pay for the mechanical work if I had the money. I like working on cars, it's kind of therapudic, it's just the conditions are never ideal. It's always freezing or there's not enough time or something. It's never warm, I've got all weekend and there's never beer in the fridge when the work needs to be done.
BTW, I looked at my spark plug wires on my last break. It looked like one was touching the engine block but I didn't see any exposed copper. It could be shorting to the engine block through the insulation, I guess. Anyway, I moved it back and started it in the parking lot, seems ok...
I'd pay for the mechanical work if I had the money. I like working on cars, it's kind of therapudic, it's just the conditions are never ideal. It's always freezing or there's not enough time or something. It's never warm, I've got all weekend and there's never beer in the fridge when the work needs to be done.
BTW, I looked at my spark plug wires on my last break. It looked like one was touching the engine block but I didn't see any exposed copper. It could be shorting to the engine block through the insulation, I guess. Anyway, I moved it back and started it in the parking lot, seems ok...
Paul of Dune was so bad it gave me a seizure that dislocated both of my shoulders and prolapsed my anus.
~Pink Snowman
On Car conditions
Not ever warm? Come down here in the spring-time, You'll probably ditch your shirt real fast. Its easy to get beer.
I know a little lot you can work at...
I know a little lot you can work at...
- Freakzilla
- Lead Singer and Driver of the Winnebego
- Posts: 18454
- Joined: 05 Feb 2008 01:27
- Location: Atlanta, Georgia, USA
- Contact:
You rarely make sense, and when you do it's offensive.
Anyway...
I now have airflow but it only comes out warm when I'm moving, it doesn't come out warm at idle... which defeats the purpose of defrost. I need to see out the windshield BEFORE I start driving.
<sigh>
Looks like I'll be replacing spark plug wires now too.
Anyway...
I now have airflow but it only comes out warm when I'm moving, it doesn't come out warm at idle... which defeats the purpose of defrost. I need to see out the windshield BEFORE I start driving.
<sigh>
Looks like I'll be replacing spark plug wires now too.
Paul of Dune was so bad it gave me a seizure that dislocated both of my shoulders and prolapsed my anus.
~Pink Snowman
- GamePlayer
- 70mm God
- Posts: 2993
- Joined: 09 Feb 2008 11:26
- Location: Toronto, Ontario, Canada
An old 1989 Jeep Cherokee I once owned had a similar problem. Even after replacing the block heater, the hot air would drop significantly upon idling. Sometimes, the heat would fail so completely that it would actually blast cold air through the vents. I tried solving the issue by installing an auxiliary heater, but it never worked well enough. Last attempt was replacing most of the ducting and ensuring all the seals on the engine were replaced. Still nothing.
If I had one word of advice for this problem, it would be to get rid of the vehicle. I spent a lot of time and money trying to fix that problem and it never did work again. Finally, I just sold the thing
If I had one word of advice for this problem, it would be to get rid of the vehicle. I spent a lot of time and money trying to fix that problem and it never did work again. Finally, I just sold the thing
"They can chew you up, but they gotta spit you out."
- Freakzilla
- Lead Singer and Driver of the Winnebego
- Posts: 18454
- Joined: 05 Feb 2008 01:27
- Location: Atlanta, Georgia, USA
- Contact:
The wierd thing is it was woking fine before the blower started to go bad.
I hope the spark plug wires didn't fry it, but I think the blower motor only controls fan speed and that works great now.
I hope the spark plug wires didn't fry it, but I think the blower motor only controls fan speed and that works great now.
Paul of Dune was so bad it gave me a seizure that dislocated both of my shoulders and prolapsed my anus.
~Pink Snowman
- Freakzilla
- Lead Singer and Driver of the Winnebego
- Posts: 18454
- Joined: 05 Feb 2008 01:27
- Location: Atlanta, Georgia, USA
- Contact:
...besides, I can't sell my pimp-mobile! What would I do with the dead hookers in the trunk?
Seriously though, if I'm going to make a 110 mile round trip commute every day it's going to be in style and comfort. It's going to be tough to beat a paid-for Caddy. I can't afford a car payment right now, full coverage insurance neither.
As long as I spend less than a car note and full coverage insurance on maintenance I'm still saving money.
Seriously though, if I'm going to make a 110 mile round trip commute every day it's going to be in style and comfort. It's going to be tough to beat a paid-for Caddy. I can't afford a car payment right now, full coverage insurance neither.
As long as I spend less than a car note and full coverage insurance on maintenance I'm still saving money.
Paul of Dune was so bad it gave me a seizure that dislocated both of my shoulders and prolapsed my anus.
~Pink Snowman
on Freakzilla
What...?Freakzilla wrote:You rarely make sense, and when you do it's offensive.
Oh I get it, you're saying I don't make snese, while not making sense yourself.
Freak's geinus lives on!
- Freakzilla
- Lead Singer and Driver of the Winnebego
- Posts: 18454
- Joined: 05 Feb 2008 01:27
- Location: Atlanta, Georgia, USA
- Contact:
I don't think they make cars to last more than three years now.Crysknife wrote:Well that was your first problem.An old 1989 Jeep Cherokee
I swear Jeeps were made to biodegrade after 5 years.
And people wonder why our economy and the auto industry is in the shitter.
Build me a car that I can hand down to my kids and I'll buy it. Until that happens I can keep a used car running for three years for a few grand.
Paul of Dune was so bad it gave me a seizure that dislocated both of my shoulders and prolapsed my anus.
~Pink Snowman
- GamePlayer
- 70mm God
- Posts: 2993
- Joined: 09 Feb 2008 11:26
- Location: Toronto, Ontario, Canada
Just start singing "dirty crack whore and I don't care" and all your pimp-mobile problems melt awayFreakzilla wrote:...besides, I can't sell my pimp-mobile! What would I do with the dead hookers in the trunk?
Seriously though, I understand. The last thing you want to do is buy a new car in this economic climate. I just wanted to warn you about the trap of an old auto. One really has to be prepared to take a good look at what it's ultimately costing to keep it running. I kept my Jeep for a few years longer than I should have and I'll never make that same mistake again. But if you're still ahead at this point, best to keep your ho-hummer
Actually, it lasted 10 years before parts started to go, but most automobiles seem to have some terrible 4 year life span. Who knew Tyrell Corporation started out with carsCrysknife wrote:Well that was your first problem.An old 1989 Jeep Cherokee
I swear Jeeps were made to biodegrade after 5 years.
"They can chew you up, but they gotta spit you out."
- SandChigger
- KJASF Ground Zero
- Posts: 14492
- Joined: 08 Feb 2008 22:29
- Location: A continuing state of irritation
- Contact:
on my suicidal thoughts
Time to die.
*You guys hear a loud loud gunshot from some distance away*
*You guys hear a loud loud gunshot from some distance away*
- Omphalos
- Inglorious Bastard
- Posts: 6677
- Joined: 05 Feb 2008 11:07
- Location: The Mighty Central Valley of California
- Contact:
- Robspierre
- Posts: 2162
- Joined: 19 Feb 2008 10:49
- Location: Cascadia
Toyota Corolla's or Honda Civics. My brother is driving a 96 Corolla with 260,000 + miles on it and is still averaging 45 MPG. Regular oil changes and routine maintenance and these rice burners run forever.Freakzilla wrote: Build me a car that I can hand down to my kids and I'll buy it. Until that happens I can keep a used car running for three years for a few grand.
Rob
- Freakzilla
- Lead Singer and Driver of the Winnebego
- Posts: 18454
- Joined: 05 Feb 2008 01:27
- Location: Atlanta, Georgia, USA
- Contact:
Thanks, but I haven't owned a new car in like ten years. I can fix most things that aren't inside the engine or transmission. I can do a lot of work on a car for under $500 a month, which is what a new car+insurance might cost. I have to have a car I can fit the whole family of six in too. I think the '95 Caddy is probably the most well-built car I've ever had.GamePlayer wrote:Seriously though, I understand. The last thing you want to do is buy a new car in this economic climate. I just wanted to warn you about the trap of an old auto.
Plus, the 4.9L V-8 makes me throb. VROOOOOM!
Paul of Dune was so bad it gave me a seizure that dislocated both of my shoulders and prolapsed my anus.
~Pink Snowman
- Freakzilla
- Lead Singer and Driver of the Winnebego
- Posts: 18454
- Joined: 05 Feb 2008 01:27
- Location: Atlanta, Georgia, USA
- Contact:
I hear ya, but how well does a family of six fit in a Corolla or a Civic?Robspierre wrote:Toyota Corolla's or Honda Civics. My brother is driving a 96 Corolla with 260,000 + miles on it and is still averaging 45 MPG. Regular oil changes and routine maintenance and these rice burners run forever.Freakzilla wrote: Build me a car that I can hand down to my kids and I'll buy it. Until that happens I can keep a used car running for three years for a few grand.
Rob
Paul of Dune was so bad it gave me a seizure that dislocated both of my shoulders and prolapsed my anus.
~Pink Snowman
- Freakzilla
- Lead Singer and Driver of the Winnebego
- Posts: 18454
- Joined: 05 Feb 2008 01:27
- Location: Atlanta, Georgia, USA
- Contact:
The middle child? JUST KIDDING! I LOVE YOU SPENCER!Baraka Bryan wrote:Freakzilla wrote:I hear ya, but how well does a family of six fit in a Corolla or a Civic?Robspierre wrote:Toyota Corolla's or Honda Civics. My brother is driving a 96 Corolla with 260,000 + miles on it and is still averaging 45 MPG. Regular oil changes and routine maintenance and these rice burners run forever.Freakzilla wrote: Build me a car that I can hand down to my kids and I'll buy it. Until that happens I can keep a used car running for three years for a few grand.
Rob
two in the front, three in the back, one strapped to the roof.. (there's always that one kid you don't care about quite as much )
What am I thinking? The step-son goes on the roof. Duh...
Paul of Dune was so bad it gave me a seizure that dislocated both of my shoulders and prolapsed my anus.
~Pink Snowman
- SandRider
- Watermaster
- Posts: 6163
- Joined: 05 Oct 2008 16:14
- Location: In the back of your mind. Always.
- Contact:
my farm truck is a 1986 Chevy Scottsdale.
have no idea how many miles are on it, changed out transmissions
in the mid-nineties and the speedo and odometer ain't worked
right since, but I'm guessing it's up over 500K. Tough ass truck,
will pull a house down. Gets about 8 mpg, tho.
my travelling car is a 2001 Buick Century, and sweet. Smooth,
quiet, stupidly comfortable. I've got 250K on it right now, and have
had absolutely ZERO problems with it. It'll average 38 mpg, and on
one trip on the section of I-80 where you can do 80-85 mph, I got 52 mpg.
V-6, so there's not alot of quick pick-up, if you stomp on it, it'll drink
gas, but a smooth steady foot does well.
I've had my share of bullshit cars & trucks, too, tho. As to the maintence
problems, Freak, get you a personal Mexican.
have no idea how many miles are on it, changed out transmissions
in the mid-nineties and the speedo and odometer ain't worked
right since, but I'm guessing it's up over 500K. Tough ass truck,
will pull a house down. Gets about 8 mpg, tho.
my travelling car is a 2001 Buick Century, and sweet. Smooth,
quiet, stupidly comfortable. I've got 250K on it right now, and have
had absolutely ZERO problems with it. It'll average 38 mpg, and on
one trip on the section of I-80 where you can do 80-85 mph, I got 52 mpg.
V-6, so there's not alot of quick pick-up, if you stomp on it, it'll drink
gas, but a smooth steady foot does well.
I've had my share of bullshit cars & trucks, too, tho. As to the maintence
problems, Freak, get you a personal Mexican.
................ I exist only to amuse myself ................
I personally feel that this message board, Jacurutu, is full of hateful folks who don't know
how to fully interact with people. ~ "Spice Grandson" (Bryon Merrit) 08 June 2008
I personally feel that this message board, Jacurutu, is full of hateful folks who don't know
how to fully interact with people. ~ "Spice Grandson" (Bryon Merrit) 08 June 2008
- Freakzilla
- Lead Singer and Driver of the Winnebego
- Posts: 18454
- Joined: 05 Feb 2008 01:27
- Location: Atlanta, Georgia, USA
- Contact:
on Freak's childrens
Your wife typed that, right?Freakzilla wrote: The middle child? JUST KIDDING! I LOVE YOU SPENCER!
Please God tell me your wife typed that.
- Freakzilla
- Lead Singer and Driver of the Winnebego
- Posts: 18454
- Joined: 05 Feb 2008 01:27
- Location: Atlanta, Georgia, USA
- Contact:
Re: on Freak's childrens
I don't let my wife on here. You've got to have your own space.Sole Man wrote:Your wife typed that, right?Freakzilla wrote: The middle child? JUST KIDDING! I LOVE YOU SPENCER!
Please God tell me your wife typed that.
Is there something wrong with loving your children?
Oh wait... I get it... it all makes sense to me now...
Paul of Dune was so bad it gave me a seizure that dislocated both of my shoulders and prolapsed my anus.
~Pink Snowman